Samsung SCX-5315F/5115 Manuale di Servizio

DIGITAL LASER MFPSCX-5315F SeriesSCX-5315FSCX-51151. Precautions2. Specifications3. Disassembly4. Troubleshooting5. Exploded Views and Parts List6. Blo

Disassembly and Reassembly 3-4Samsung Electronics 10. Pull the OPE Ass'y and unplug the one connector. 11. Remove the five screws securing the P

Block DiagramsSamsung Electronics 6-1 6. Block DiagramsMODEM33.6KbpsSPGPmARM946ESCACHE(16K*2)SDRAMCROMCDMACPVCGEU/HCT/gCODECI/O I/FEngine ControlI

Connection DiagramsSamsung Electronics 7-1 7. Connection DiagramsFlash DIMMPS3 (2MB)CN29 (100P)SDRAM DIMM16/32MBCN28 (100P)DEV MOTORSMPS / HVPS+5V/

Connection Diagrams7-2 Samsung Electronics CON No. Pin No.DescriptionCN1EXIT1 5VCC2 EXIT SENSOR3 GNDCON No. Pin No.CON No. Pin No.CON No. Pin No.CON

Connection DiagramsSamsung Electronics 7-3 Memo

Disassembly and Reassembly Samsung Electronics3-5 14. Remove the four screws and Channel Base Frame.15. Remove the five screws and Dummy Scan-Lower.

Disassembly and Reassembly 3-6Samsung Electronics 19. Remove the OPE Harness from the Platen PBA. Remove two screws and take out the Platen PBA.

Disassembly and Reassembly Samsung Electronics3-7 3-4 ADF Ass'y 1. Before you remove the ADF Ass'y, you should remove: -

Disassembly and Reassembly 3-8Samsung Electronics 6. Take out the Pick-up Ass’y. Remove the four screws and the ADF Uppe

Disassembly and Reassembly Samsung Electronics3-9 3-5 OPE Ass'y 1. Before you remove the OPE Ass'y, you should remove: - Rear

Disassembly and Reassembly 3-10Samsung Electronics 3-6 Side Cover Ass'y 1. Remove the two screws to release the Stop-per(Main Frame side) sec

Disassembly and Reassembly Samsung Electronics3-11 * Duplex Ass’y 1. To remove the Duplex Ass'y from the Side Door Ass' locate the plastic

Disassembly and Reassembly 3-12Samsung Electronics 3-7 Fuser Ass'y 1. Before you remove the Fuser Ass'y, you should ensure power is off

Disassembly and Reassembly Samsung Electronics3-13 6. Remove the two screws and take out the Halo-gen Lamp. 7. Remove 2 screws and hinge open the Lo

Specification Samsung Electronics2-1 2. Specification Specifications are correct at the time of printing. Product specifications are subject to change

Disassembly and Reassembly 3-14Samsung Electronics 3-8 Exit Ass'y 1. Before you remove Exit Ass'y, you should remove: - Rear C

Disassembly and Reassembly Samsung Electronics3-15 3-10 Drive Ass'y 1. Before you remove the Drive Ass'y, you should remove:

Troubleshooting Samsung Electronics 4-1 4. Maintenance & Troubleshooting This chapter covers product maintenance, problem diagnosis and troubles

Troubleshooting 4-2Samsung Electronics 4-2 Error Messages Error Message Description Solution RETRY REDIAL? The machine is waiting for the programmed

Troubleshooting Samsung Electronics 4-3 DRUM WARNING A warning that the OPC drum has almost reached the end of its life (14,000 Sides)You have 1000 p

Troubleshooting 4-4Samsung Electronics 4-3 User Mode The table below shows the settings and functions available in the User Mode. These are describ

Troubleshooting Samsung Electronics 4-5 4-3-2 SCX-5115 4-4 Tech Mode 4-4-1 How to Enter Service Mode In service mode (tech) mode, the technician can

Troubleshooting 4-6Samsung Electronics 4-4-2 Setting-up System in Tech Mode 4-4-2-1 SCX-5315F(SETUP : #, 1, 9, 3, 4)✳❑n❄❏❊on✳❑n❄❏❊on✳❑n❄❏❊on✳❑n❄❏❊on

Troubleshooting Samsung Electronics 4-7 4-4-2-2 SCX-5115(SETUP : #, 1, 9, 3, 4) REPORTS MSG. CONFIRMSCHEDULE JOBPHONE BOOKSYSTEM DATATRANSMISSIONREC

Troubleshooting 4-8Samsung Electronics 4-4-3 SYSTEM DATA DIALING MODE Select the dialing mode according to the user's line status.TONE: Electric

SpecificationSamsung Electronics2-2 2-2 Printer Specifications * Print speed will be affected by Operating System used, computing performance, applicat

Troubleshooting Samsung Electronics 4-9 4-4-5 MAINTENANCE CLEAN DRUM Use this feature to remove toner particles remaining in the OPC drum unit.Use th

Troubleshooting 4-10Samsung Electronics CLEAR COUNT This function erases the counters stored in system memory. These are shown in the highlighted are

TroubleshootingSamsung Electronics 4-11NOTIFY TONER LOWWith this feature enabled, when the toner becomes low, the toner low information will be sent t

Troubleshooting4-12Samsung ElectronicsRECEPTIONThis journal shows information relating to document reception, the time and dates of up to 40 of the mo

TroubleshootingSamsung Electronics 4-13DOS Command modeThis method is just for Parallel Port. Connect to PC with Parallel cable and enter DOS Command

Troubleshooting4-14Samsung Electronics4-5 ENGINE TEST MODEThe Engine Tests Mode provides useful test functions for checking the status of the print en

TroubleshootingSamsung Electronics 4-154-6 Troubleshooting4-6-1 Scanner4-6-1-1 COPY PROBLEM ITEMS TO BE CHECKED. HOW TO SOLVEWhite copy • Ensure t

Troubleshooting4-16Samsung Electronics4-6-1-2 PC-Scan PROBLEM ITEMS TO BE CHECKED. HOW TO SOLVEScanning Error • Check the printer cable is correctly

TroubleshootingSamsung Electronics 4-174-6-2 FAX(only SCX-5315F)4-6-2-1 FAX/TELEPHONE Precautions PROBLEM ITEMS TO BE CHECKED. HOW TO SOLVETEL LINE

Troubleshooting4-18Samsung Electronics4-6-3 Print QualityError Status Check SolutionVertical black line and band1. Faulty Toner cartridge 2. LSU3. Ba

Specification Samsung Electronics2-3 2-4 Scanner Specification * Speed will be affected by Operating System used, computing performance, application so

TroubleshootingSamsung Electronics 4-19Background 1. High voltage output is normal? 2. C/R of Toner cartridge is contaminated?1. Change the HVPS Board

Troubleshooting4-20Samsung ElectronicsAbnormal Image Printing and Defective RollerIf abnormal image prints periodically, check the parts shown below.D

Troubleshooting Samsung Electronics 4-21Check connection to computer or replace controllerTake out the cartridge and prepare the tester for electron

Troubleshooting 4-22Samsung ElectronicsTransfer roller might be out of its location -> Locate the roller into its placeThis could occurs when he

Troubleshooting Samsung Electronics 4-23 All black in printing area?Is charge voltage supplied from HVPS?Is the Hsync/ signal received in LSU?Charge

Troubleshooting 4-24Samsung Electronics White line missing definitely?Dirt of dust stuck onto the window of internal lens of LSU -> Clean it or re

Troubleshooting Samsung Electronics 4-25 Dark selected via RCP?Change to Normal and testWorks cor with -300V of Bias voltage?Works correctly after re

Troubleshooting 4-26Samsung Electronics Recommended paper used?Transfer, charge and developing voltage are OK?Operating/storage atmosphere is too hig

Troubleshooting Samsung Electronics 4-27 YESIs it regular interval of 95mm?PTL lamp works OK? Transfer voltage is set to standard?Is it regular inter

Troubleshooting 4-28Samsung Electronics Black SpotIs it regular interval of 38mm?The problem occured since the obstacles stuck to charge roller->

SpecificationSamsung Electronics2-4 2-6 Telephone Specification(SCX-5315F Only) 2-7 Consumables Item Description Speed Dial 80EATone/Pulse Tone only u

Troubleshooting Samsung Electronics 4-29 NOBlack band?The black band has regular interval?Black band is far about 95mm from white band?Problem of int

Troubleshooting 4-30Samsung Electronics OK after taking out and rocking the toner cartridge?It is over the guaranty life of toner cartridge (Check th

Troubleshooting Samsung Electronics 4-31 Is it regular interval of 95mm?Obstacles stuck on OPC's surface -> Clean the OPC and machine or

Troubleshooting 4-32Samsung Electronics Recommended OHP film used?Inserted over than 10 films into the MPF?When multi-page OHP printng, less than 10

Troubleshooting Samsung Electronics 4-33 After printing completed, any error related fuser?Both ends of thermostat open? Replace thermostat and re-te

Troubleshooting 4-34Samsung Electronics 4-6-4 Malfunction Error Status Check Solution No power 1. Check power is supplying2. Check fuse F1 open1. If

Troubleshooting Samsung Electronics 4-35 Error Status Check Solution Jam 2 at face-down tray 1. Then paper is not drawn in because of the stack of pa

Troubleshooting 4-36Samsung Electronics Plug in the power cord?The power voltage supplying is the same as rating?The fan revolves when powered on?LED

Troubleshooting Samsung Electronics 4-37 Less than 10W?AC is being supplied?The voltage of pin #60 of U36 (CPU) on the Main PBA is about 2.65V when p

Troubleshooting 4-38Samsung Electronics Sounds the solenoid on when starts print?Does the paper move? Does the paper move more than 100mm?The Main PB

T I D I This service manual is also provided on the web, the ITSELF system Samsung Electronics Co., Ltd.“http://itself.sec.samsung.co.kr”© Samsung El

Troubleshooting Samsung Electronics 4-39 Paper stopped before the OPC?Check the LSU and if it has the defect replace itPaper stopped before the fuser

Troubleshooting 4-40Samsung Electronics Check CBF Harness-CN7(Main B'D to LSU)Check Main B'D CN7-9,P_MOTOR Signal( )Check Main B&

Troubleshooting Samsung Electronics 4-41 4-6-5 Toner Cartridge and Drum Cartridge Service It is not guaranteed for the default caused by using other

Troubleshooting 4-42Samsung Electronics 4-6-5-1 Signs and Measures at Poor toner cartridge Fault Signs Cause & Check Solution Light image and p

Troubleshooting Samsung Electronics 4-43 White Black spot • Light or dark black dots on the image occur periodically.• White spots occur in the imag

Troubleshooting 4-44Samsung Electronics Ghost & Image Contamination• The printed image is too light or dark, or partially contami-nated black.• T

Troubleshooting Samsung Electronics 4-45 4-6-6 The cause and solutions of bad environment of the software 4-6-6-1 The printer is not working (1) 4-

Troubleshooting 4-46Samsung Electronics 4-6-6-3 Abnormal Printing 4-6-6-4 SPOOL Error Check and Cause Solution 1. Set up the parallel port in the

Exploded Views and Parts List Samsung Electronics 5-1 5. Exploded View & Parts List 5-1. Main Exploded View & Parts List...

Exploded Views and Parts List 5-2Samsung Electronics 5-1. Main Exploded View & Parts List938371-2(SCX-5315F)1-2(SCX-5115)1-114948404141-141-441-2

Disassembly and Reassembly Samsung Electronics3-1 3. Disassembly and Reassembly 3-1 General Precautions on Disassembly When you disassemble and r

Exploded Views and Parts List Samsung Electronics 5-3 Main Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 1 ELA HOU-SCANNER JC96-02718A 1 O SCX-51

Exploded Views and Parts List 5-4Samsung Electronics Main Parts List (Cont.) NO DESCRIPTION SEC CODE Q’TY SA REMARK 25 PMO-COVER EXIT REAR JC72-00790

Exploded Views and Parts List Samsung Electronics 5-5 5-2. Platen Ass’y Exploded View & Parts List1-1-11-11-1-21-1-4S1S11-1-31-21-31-51-4S2S2S21-

Exploded Views and Parts List 5-6Samsung Electronics3-13-23-33-43-213-53-63-73-83-93-103-113-123-133-143-153-163-173-183-193-203-13-23-33-43-123-53-6

Exploded Views and Parts List Samsung Electronics 5-7 Platen Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-PLATEN JC96-02748A 1 O

Exploded Views and Parts List 5-8Samsung Electronics SCX-5315F (OPE) SCX-5115 (OPE) NO DESCRIPTION SEC CODE Q’TY SA REMARK 3 ELA HOU-OPE JC96-02749A

Exploded Views and Parts List Samsung Electronics 5-9 5-3. ADF ASS’Y Exploded View & Parts List4-54-114-744-63-93-103-113-123-16522-12-22-62-32-4

Exploded Views and Parts List 5-10Samsung Electronics ADF Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-ADF JC96-02750A 1 O1 MEA

Exploded Views and Parts List Samsung Electronics 5-11 ADF Ass’y Parts List(Cont.) NO DESCRIPTION SEC CODE Q’TY SA REMARK 3-16 TAPE ETC-ANTI BRUSH

Exploded Views and Parts List 5-12Samsung Electronics 5-4. Side Cover Ass’y Exploded View & Parts List10-772061210-610-1810-210-310-410-51005S6S6

Disassembly and Reassembly 3-2Samsung Electronics 3-3 Scanner Ass'y 1. Before you remove the Scanner Ass'y, you should remove:

Exploded Views and Parts List Samsung Electronics 5-13 Side Cover Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-SIDE COVER JC96-0

Exploded Views and Parts List 5-14Samsung Electronics 5-5. Cassette Ass’y Exploded View & Parts List031114137S6S68161610231251522229211719201918

Exploded Views and Parts List Samsung Electronics 5-15 Cassette Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 MEC-CASSETTE PLUS ASS’Y JC9

Exploded Views and Parts List 5-16Samsung Electronics 5-6. Exit Ass’y Exploded View & Parts List785510S62022466101049212121111161715183131912142S

Exploded Views and Parts List Samsung Electronics 5-17 Exit Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 MEA UNIT-EXIT ASS’Y JC97-01643A

Exploded Views and Parts List 5-18Samsung Electronics 5-7. Feeder Ass’y Exploded View & Parts List2176537104208S61112S6S6121317175191915181214216

Exploded Views and Parts List Samsung Electronics 5-19 Feeder Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 MEA-FEED ASS’Y JC75-00143B 1

Exploded Views and Parts List 5-20Samsung Electronics 5-8. MP Ass’y Exploded View & Parts List181212216620202321451093S584S912172413231171915

Exploded Views and Parts List Samsung Electronics 5-21 MP Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-MP ASS’Y JC96-02182A 1 O1

Exploded Views and Parts List 5-22Samsung Electronics 5-9. Base Frame Exploded View & Parts List18111201415171161412131155107318192916

Disassembly and Reassembly Samsung Electronics3-3 6. Pull up the Scanner Ass'y in the direction of arrow. 7. Remove the connector from the P

Exploded Views and Parts List Samsung Electronics 5-23 Base Frame Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-BASE FRAME JC96-02818A

Exploded Views and Parts List 5-24Samsung Electronics 5-10.Pick-up Ass’y Exploded View & Parts List611205S104212973180132422221423151817162119221

Exploded Views and Parts List Samsung Electronics 5-25 Pick-up Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-PICKUP PLUS ASS’Y JC

Exploded Views and Parts List 5-26Samsung Electronics 5-11. Drive Ass’y Exploded View & Parts ListS10122410232311S1S10S10121314 23152318171623192

Exploded Views and Parts List Samsung Electronics 5-27 Drive Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-DRIVE(15PPM) JC96-0274

Exploded Views and Parts List 5-28Samsung Electronics 5-12. Main Frame Ass’y Exploded View & Parts List31321223S515S521411109867325S5141720S41816

Exploded Views and Parts List Samsung Electronics 5-29 Main Frame Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-FRAME MAIN ASS’Y

Exploded Views and Parts List 5-30Samsung Electronics 5-13. FuserAss’y Exploded View & Parts List242323-123-423-2181916171722152526S6S5211620S5S

Exploded Views and Parts List Samsung Electronics 5-31 Fuser Ass’y Parts List NO DESCRIPTION SEC CODE Q’TY SA REMARK 0 ELA HOU-FUSER JC96-02814A 1 O

Exploded Views and Parts List 5-32Samsung Electronics 5-14. Screw NO SEC CODE DESCRIPTION SPEC. S1 6006-000127 SCREW-ASS’Y MACHWS,PH,+,M3,L6,ZPC(YEL